Polaris Scrambler 400L

1999 Polaris Scrambler L 4X4

So I picked up this Scrambler 400 as a project. The engine was seized, the plastic was off it and it was sitting outside for over 6 years. The videos below show my restoration of this beast!!

Started by un-Seizing the engine, which was not too bad because it was set up from sitting. PB Blaster and a few hours the piston was free and I squirted some gas in the intake boot with the carb off and it fired right up! Then I rebuild the carb, emptied the mouse nests out of the CVT drive, put the carb back on and took it for a ride!

For the best prices, click the links below!

Scrambler gas cap with gauge

Scrambler gas cap w gauge http://amzn.to/2cTbCEk

All Balls CV boot Scrambler

All Balls front CV boot http://amzn.to/2dT5A3M

Gates Drive belt

Gates CVT Drive Belt http://amzn.to/2cTcLf9

3 way valve Polaris

3 way Fuel valve (n-off-reserve) https://goo.gl/uz7MF0

Needs longer hoses to install

Scrambler 400 maint free battery

Polaris Scrambler Maint free battery https://goo.gl/My8LRv

Polaris Scrambler 400 Starter

NEW Polaris Scrambler Starter https://goo.gl/NT6mUr

5/16" 25' fuel line

Fuel line 5/16" 25' roll https://goo.gl/tcK2G9

Zoan XL helmet BLACK

The Zoan Helmet I wear while Motovlogging http://amzn.to/2dtwuRw

Tire tube emergency air and repair

Tire tube repair kit http://amzn.to/2dThfQj

Chain break rivet tool

ATV/Motorcycle Chain Break, Cut, Rivet tool http://amzn.to/2dX8wfE

Type F

Demand drive hubs fluid Type F http://amzn.to/2dXWhjc

Synthetic gear lube

75w-140 Synthetic gear oil http://amzn.to/2dAnV6A

Chain Wax Dry

DuPont Teflon Chain-Saver Dry Self-Cleaning Lubricant http://amzn.to/2dXxPho

GoPro Mic In Helmet

GoPro Mic for in Helmet http://amzn.to/2euJ7eL


Acarte Carburetor Carbon Dirt Jet Cleaner Tool Kit 10 Cleaning Needles with 5 Brushes


MANUALS at bottom of page:

The following videos will be going over the entire machine, changing the starter, all the oils including the counter-shaft oil, which is forgotten a lot because it's a 2 stroke. I make no claims to be an expert mechanic, there are other ways and mine may not always be the "correct" way.

If you're interested in the restore, please follow me on Youtube!